750,000 Gallon Fluted Column (McKinley Road Tank) Wet Interior Repaint, Dry Interior Partial Repaint, and Miscellaneous Repairs
SECTION 00 00 30
NOTICE to BIDDERS
City of St. Marys
101 East Spring Street St. Marys, OH 45885
Separate sealed Bids are solicited for the following project:
Project Name: 750,000 Gallon Fluted Column (McKinley Road Tank) Wet Interior Repaint
Dry Interior Partial Repaint
And Miscellaneous Repairs
Note: This project name shall be understood to include the entire scope of project as defined and detailed by these specifications.
The structure is a 750,000 gallon fluted column elevated water storage tank with a low water line of 89.5 feet located on McKinley Rd., St. Marys, Ohio.
Scope of Work:
Wet Interior: Abrasive blast clean to a SSPC-SP10 near white metal standard, and apply a three (3) coat zinc epoxy system. The cathodic protection system shall be removed and reinstalled by the owner’s vendor, coordination and payment is the contractor’s responsibility.
Dry Interior: Abrasive blast clean the entire tops of the platforms (including 1 ft. up the riser wall), the bowl, the access tube, and spot failures throughout to a SSPC-SP6 commercial standard, and apply a three (3) coat epoxy system to the access tube and bowl, and a spot two (2) coat epoxy system to the rest of the prepared surfaces.
Mixer: Install a mechanical mixer in the wet interior.
1) Replace bowl manway gasket.
2) Install handholds at the roof hatches.
3) Install mud valve and access ladder.
4) Replace dry interior and aviation light bulbs.
Separate sealed bids will be received by the Owner and then publicly opened and read aloud at:
Bid Opening Site: City Office, 101 E. Spring St., St. Marys, OH
Bid Opening Date: August 1, 2017
Bid Opening Time: 2:00P.M. (local time)
The SPECIFICATIONS /PLANS may be examined at the following locations:
Toledo Builders Exchange, 5555 Airport Hwy., Suite 140, Toledo, OH 43615
Construction Association, 43636 Woodward Ave., Bloomfield Hills, MI 48302
Central Michigan Plan Room, 2026 Independence Dr., Mt. Pleasant, Ml 48858
At the OFFICE of the ENGINEER and at the OFFICE of Jeff Thompson, Superintendent of Water and Sewer Departments.
Copies of the SPECIFICATIONS/PLANS and PROPOSAL FORMS may be obtained at the office of DIXON ENGINEERING, INC., 1104 Third Avenue, Lake Odessa, Michigan, 48849 upon payment of $60.00 (handling charge for each set). Payment for SPECIFICATIONS should be made to Dixon Engineering, Incorporated. There will be no refund of handling charge for return of specification packages. Each BIDDER must deposit with their BID, Security in the amount, form, and subject to the conditions provided in the INFORMATION FOR BIDDERS. The OWNER reserves the right to accept any PROPOSAL, to reject any or all PROPOSALS, and to waive any irregularities in any PROPOSAL. No BIDDER may withdraw their BID within sixty (60) days after the actual date of the opening thereof.
Note 1: The Engineer assumes no responsibility to supply Builders Exchanges and similar plan review rooms with all addenda issued. An attempt will be made to do so; however, only registered plan holders will be notified by fax of expected addendum with short preparation times.
Note 2: Prequalification of BIDDERS -Dixon Engineering will review qualifications of all Contractors and determine their status. Contractors will be prequalified for different sized tanks and towers based on experience, workmanship, and financial data. Any Contractor who has any projects in dispute or unfinished because of Contract problems will be considered NOT prequalified. CONTRACTORS wishing to be prequalified must submit their latest financial statement and a list of ten (10) similar sized projects using similar coating systems. Failure to submit may result in rejection of bid. A prequalification status may be upgraded or downgraded during the course of the season as a result of new data submitted, resolution or origination of project conflicts.
Not less than the prevailing rate of wages as found by the City of St. Marys, or the Department of Labor, or determined by the court on review shall be paid to all laborers, workmen, and mechanics performing work under this contract.
Publish: July 15, 2017
July 22, 2017